I believe many people have seen rolling shutter doors. Most of them are used in garage or small shop facade decoration. In the past, rolling shutter doors were usually opened with keys and used manually, but now with remote control rolling shutter doors, it is more convenient to use, but there are many problems in its use.

一、遥控卷帘门的使用

1、 Application of remote control rolling shutter door

1、清码

1. Clear code

同时按下遥控器上排的两个按键指示灯闪一次后约2秒后快闪即表示清 除成功。清 除之后按遥控器四个按键指示灯仅闪一下后熄灭。

Press the two buttons on the upper row of the remote control at the same time, and the indicator light will flash about 2 seconds after flashing once, indicating that the clearing is successful. After clearing, press the four buttons on the remote control, and the indicator light will only flash once and then go out.

2、对拷

2. Torture

将原遥控器与对拷遥控器并排摆放，同时按下两个遥控器任意按键，对拷型遥控器指示灯快闪即表示复制成功。

Place the original remote controller and the copy remote controller side by side, press any key of the two remote controllers at the same time, and the copy remote controller indicator light flashes quickly, which indicates that the copy is successful.

3、恢复

3. Recovery

(1)若误操作清 除掉有用代码后，在没有重新拷贝其他遥控器之前可同时按下遥控器下排两个按键2秒后指示灯快速闪烁则恢复。

(1) If the useful code is cleared by misoperation, the two buttons on the lower row of the remote controller can be pressed at the same time before copying other remote controllers again. After 2 seconds, the indicator light will flash quickly to restore.

(2)新款卷帘门遥控器，四个按键分别可以对拷四种不同类型的芯片，也就是一个卷帘门遥控器可以操作四种不同类型的设施。

(2) The new rolling shutter door remote controller, four buttons can copy four different types of chips, that is, a rolling shutter door remote controller can operate four different types of facilities.

4、注意型号

4. Pay attention to the model

确定你的遥控器是哪种遥控器，知道自己遥控器的晶频型号，芯片型号。

Determine what kind of remote control your remote control is, and know the crystal frequency model and chip model of your remote control.

二、遥控卷帘门的常见问题

2、 Common problems of remote control rolling shutter door

1、电动机不动或转速慢

1. The motor does not move or the speed is slow

一般是线路断路、电机烧损、停止按钮没复位、限位开关动作、负载较大等引起。

Generally, it is caused by line open circuit, motor burning, no reset of stop button, action of limit switch, large load, etc.

2、控制失效

2. Control failure

继电器触点粘死、行程微动开关失效或触片变形、滑块紧定螺钉松、靠板螺丝松使靠板移位，使滑块或螺母不能随丝杆转动而移动、限位器传动齿轮破损、按钮上、下键卡死。

The relay contact is stuck, the travel micro switch is invalid or the contact piece is deformed, the fastening screw of the slide block is loose, the screw of the back plate is loose, which makes the back plate shift, so that the slide block or nut can not move with the screw rod, the transmission gear of the limiter is damaged, and the up and down keys of the button are stuck.

3、手拉链不动

3. Hand zipper does not move

环形链条堵住十字槽;棘爪无脱离棘轮，压链架卡死。

The ring chain blocks the cross groove; The pawl is not separated from the ratchet wheel, and the chain press frame is stuck.

4、电机振动或噪声较大

4. The motor has large vibration or noise

刹车盘不平衡或断裂;刹车盘无紧固;轴承失油或失效，齿轮啮合不顺、失油或磨损严重;电机电流声或振动.

The brake disc is unbalanced or broken; The brake disc is not fastened; Bearing oil loss or failure, gear meshing is not smooth, oil loss or serious wear; Motor current, sound or vibration

5、如果长期缺乏保养，导致电动卷闸门存在的隐患及小故障得不到及时处理，马达得到一定运行电流后做正向运行，将动力传给同步带，再由同步带将动力传给吊具系统使门扇开启。

5. If there is no maintenance for a long time, the hidden dangers and small faults of the electric roller gate can not be dealt with in time. After the motor gets a certain operating current, it will run in a positive direction and transmit the power to the synchronous belt, and then the synchronous belt will transmit the power to the spreader system to open the door leaf.

6、驱动器每年少要加注一次润滑脂，链条应经常加注润滑油，并检查各部件磨损情况，磨损严重的机件要及时维修或更换。

6. The drive should be filled with lubricating grease at least once a year, the chain should be filled with lubricating oil frequently, and the wear condition of all parts should be checked. The seriously worn parts should be repaired or replaced in time.

以上是遥控卷帘门的使用与常见问题，上述问题希望可以帮到大家。

The above is the use of remote control shutter door and common problems, the above problems can help you.